Experimental Investigation of Critical Heat Flux on Different Surfaces at Low Pressure and Low Flow

Experimental Investigation of Critical Heat Flux on Different Surfaces at Low Pressure and Low Flow

Článek WoS

Steady state flow boiling experiments were carried out on several heated tubes with outer diameter 9.14 mm at outlet pressures 120, 200 and 300 kPa, inlet temperatures 64, 78 and 91 °C and approximately 400, 500, 600 and 800 kg/(m2·s) mass flux entering the vertically aligned test annulus until critical heat flux (CHF) was reached. The tubes were made of Inconel 625 with a length of 400 mm. The Inconel tubes were tested in three different modifications as smooth, abraded with 150 grit sandpaper and bead blasted. Multiple experiments were repeated on the same specimen to investigate the effect of surface characteristic changes (i.e., wettability, roughness and oxide layer morphology) on the occurrence of CHF. Despite the changes in initial wettability, the CHF dependency was not clearly observed, however, the changes in roughness led to an increase in CHF. The total number of 115 experimental runs were collected and the results were also compared with other literature experimental data.

Steady state flow boiling experiments were carried out on several heated tubes with outer diameter 9.14 mm at outlet pressures 120, 200 and 300 kPa, inlet temperatures 64, 78 and 91 °C and approximately 400, 500, 600 and 800 kg/(m2·s) mass flux entering the vertically aligned test annulus until critical heat flux (CHF) was reached. The tubes were made of Inconel 625 with a length of 400 mm. The Inconel tubes were tested in three different modifications as smooth, abraded with 150 grit sandpaper and bead blasted. Multiple experiments were repeated on the same specimen to investigate the effect of surface characteristic changes (i.e., wettability, roughness and oxide layer morphology) on the occurrence of CHF. Despite the changes in initial wettability, the CHF dependency was not clearly observed, however, the changes in roughness led to an increase in CHF. The total number of 115 experimental runs were collected and the results were also compared with other literature experimental data.

critical heat flux; flow boiling; annulus; Inconel 625; two phase flow; low pressure

critical heat flux; flow boiling; annulus; Inconel 625; two phase flow; low pressure

SUK, L.; PETROSYAN, T.; ŠTEVANKA, K.; VLČEK, D.; GEJDOŠ, P.

2021

06.10.2020

MDPI

Basel, Switzerland

1996-1073

Energies

13

19

Švýcarská konfederace

1

23

23

https://www.mdpi.com/1996-1073/13/19/5205

http://hdl.handle.net/11012/195684

energies-13-05205-v2